Goshen News, Goshen, IN

Local News

March 29, 2013

Temperature fluctuations good for maple syrup production

With temperatures trying their best to be uncooperative this spring, it is by no means curtailing activities behind the scenes.

I drive by numerous greenhouse operations that are buzzing with planting and seeding activities. In the wee hours of the morning with dawn just breaking, these operations can be seen with smoke billowing from their stacks and the whole greenhouse lit up like a jewel in the darkness. Later this same greenhouse may have its doors wide open and fans blowing to allow heat to escape.

Temperatures in a growing greenhouse ideally should hover in the 68- to 72-degree range, depending on what you are trying to grow. Sometimes it is difficult to maintain these constant temps because of the sun’s penetration into these enclosures.

Most of the older houses have roll-up sides to allow for better ventilation. But nowadays, with modern technology, most of the newer greenhouses have overhead vents that are automatically temperature controlled. Heat rises, so it makes sense to have these overhead vents to allow all that excess heat to escape.

Most of the larger operations will have at least one greenhouse that is kept cooler for plants that desire a cooler growing atmosphere or, in some cases in large operations, there will be several houses kept between 40 and 50 degree to “harden off” the cool, weather-loving plants, including early vegetables (kohlrabi, cabbage, broccoli, cauliflower and kale) when they reach an acceptable size to do this.

Early, cool-weather flowers are also treated to this “hardening off” action and they would include, among others, alyssum, snapdragons, violas, pansies, petunias and ivy geraniums. You must perform this operation in stages by decreasing the temperatures gradually to prevent shocking.

Smaller operations may prefer to provide a “cold-frame” set-up that will allow them to be open during weather conditions that permit this, or to be closed if a frost or freeze is in the forecast.

Another behind-the-scenes activity that has always intrigued me — but that I’ve never had the opportunity to watch to its fruition — is the maple syrup production process.

I pass wooded areas that have the tree tapping going on with the collection of sugar water that will eventually become the reveled maple syrup we all love so much.

Some relevant facts that people might not know are that it takes between 40 to 50 gallons of sugar water to produce one gallon of maple syrup.

February through March when temperatures fluctuate from above freezing during the day and below freezing at night is what causes the sap to flow.

The earliest harvesting of the sap was done by the American Indians who “reduced it down” by heating stones and placing them in the tree water. This would reduce the water content and leave the remaining syrup.

Tapping graduated from wooden flute-like taps to the modern metal taps that are used today. A sugar maple is considered large enough for tapping when it is 10 inches in diameter at 4½ feet above ground level. A 15-inch tree will allow two taps and a 20-inch tree can use three taps. An average tree will produce 15 gallons of sap from each tap-hole per season.

The sugar water is collected and placed in a central storage tank at the “sugar house” to start the process of filtering several times and heating to 185 degrees. This reduces the sugar water with a sugar content of 2 to 2½ percent to a sugar content of the finished product of more than 65 percent. A gallon of syrup weighs approximately 11 pounds.

1
Text Only
Local News
  • Fresh shrimp business approved GOSHEN — Finding fresh shrimp in Elkhart County just got a little easier.

    August 21, 2014

  • NWS GN140822 john hertzel (2) John Hertzler relishes role with Goshen Historical Society GOSHEN — Visitors to the Goshen Historical Society’s museum might not know John Hertzler is there, tucked back in an office beyond the rows of historic documents, photographs and artifacts.

    August 21, 2014 2 Photos

  • Lifelong Learning fall courses announced GOSHEN — The Lifelong Learning Institute of Elkhart County is offering fall courses. These short courses are designed to provide stimulating and affordable classes in many fields for active seniors. There are no tests or grades, and no previous studies or degrees are required.

    August 21, 2014

  • South Ninth Street area under boil water order South Ninth Street, between East Jackson and Franklin streets in Goshen, is under a boil water order from noon until further notice.

    August 21, 2014

  • GN140821 Pike Street Project 2 INDOT meeting held to discuss Pike Street project GOSHEN — Major changes may be on the way for a small section of Pike Street in downtown Goshen.

    August 20, 2014 2 Photos

  • 0821 goshen college challenge Locals embrace ice bucket challenge It’s a challenge that has united participants with the shared sensation of an icy burst of water, sopping wet clothing and video evidence — all in the name of philanthropy.

    August 20, 2014 1 Photo

  • GN140821 nisly complaint Complaint filed against state rep candidate Accusations of wrongdoing, in the form of a complaint to the Indiana Election Commission, have been levied against District 22 representative Republican nominee Curt Nisly.

    August 20, 2014 1 Photo

  • GN140820 dometic groundbreaking Dometic breaks ground on significant expansion in Goshen GOSHEN — As Dometic officials gathered for a groundbreaking ceremony for the $7 million expansion of their Goshen distribution center Wednesday, the work was already underway in the background. “It’s happening right now,” said Dave Schutz, vice presi

    August 20, 2014 1 Photo

  • GN140821 Ignition art Plenty of good music on horizon at Ignition Several upcoming shows at Ignition Garage in Goshen were announced this week.

    August 20, 2014 1 Photo

  • City plan nearing a final draft GOSHEN — The city’s new comprehensive plan is nearing completion, and a near-final draft has now been released for public review. Goshen Plan Commission members released the draft of the city’s newly penned comprehensive plan, titled “Uncommonly Grea

    August 19, 2014

Parade
Magazine

Click HERE to read all your Parade favorites including Hollywood Wire, Celebrity interviews and photo galleries, Food recipes and cooking tips, Games and lots more.
Poll

Three Goshen elementary schools — Chandler, Chamberlain and West Goshen — are providing free meals to all students during the school year as part of the U.S. Department of Agriculture’s Community Eligibility Provision of the Healthy Hunger-Free Kids Act of 2010. Nearly 80 percent of students at Chandler, 89 percent of students at Chamberlain and 78 percent of students at West Goshen already qualify for free or reduced-price lunches based on their family income. How do you feel about the new lunch program?

I think it’s a good idea to feed all the students free of charge
I think those who can afford it should pay for their school meals
I think all students should be required to pay for their school meals
     View Results
AP Video
Japan Landslide Rescuers Struggle in Heavy Rain Raw: Severe Floods, Fire Wrecks Indiana Homes Endangered Red Wolves Face Uncertain Future Raw: Russian Aid Convoy Arrives in Ukraine Hamm Talks Emmy Chances Okla. Policeman Accused of Sex Assaults on Duty Raw: Egypt Bus Crash Kills at Least 33 Two Bodies Found in Adjacent Yards Dominican Republic Bans Miley Cyrus Concert Raw: Israeli Air Strike in Gaza Raw: Rescue Efforts Suspended at Japan Landslide Raw: Bodies of MH17 Victims Arrive in Malaysia Raw: Smaller Marches in Ferguson Attorney: Utah Eatery Had Other Chemical Burn Farm Resurgence Grows With Younger Crowd Microbrewery Chooses Special Can for Its Beer Ky. Firefighters Hurt in Ice Bucket Challenge Federal Investigation Will Look at Use of Force Community Deals With Michael Brown Aftermath US: We Do Not Pay Ransom to Terrorists